Generator size for 11500 running watts with a 5 HP motor on diesel

Generator size

24,000watts

11,500 W running with a 5 HP motor on diesel at 5,000 ft

Running wattseverything on at once	11,500W
Starting surgerunning load plus the 5 HP motor's inrush	18,960W
After the 80% rulea generator should not run continuously above 80% of its rating	14,375W
Diesel deratelong engine life and good fuel economy; poor cold starting	none
Altitude derate5,000 ft at 3% per 1,000 ft	−15%
Rated size needed	22,306W
Nearest size sold7% headroom left	24,000W

Running watts: 11500 W
Largest motor: 5 HP
Fuel: diesel
Altitude: 5000 ft

Read this before the numbers

Carbon monoxide kills people every storm season. Outdoors only, at least 20 feet from any door, window or vent, exhaust pointed away from the house. Not in a garage, not even with the door open. Fit CO alarms indoors and treat a headache during an outage as CO until proven otherwise.

Never back-feed. Plugging a generator into a wall socket energises the utility line outside and can kill a lineman restoring your power. A transfer switch or interlock kit is the only correct connection, and it is an electrician's job.

Two numbers, not one

11,500 W running — everything on at once. 18,960 W starting — the running load plus the inrush of the single largest motor.

Only one motor's surge is counted, and that is deliberate. A motor draws about three times its running watts for a second or two on start; adding every motor's surge together, which is what most sizing tables do, buys a generator twice the size you need.

Then the derates

The 80% rule first: a generator should not run continuously above 80% of its rating, because heat is what ends them. Then fuel — diesel costs 0% of output against gasoline on the same engine. Then altitude, about 3% per 1,000 ft.

That comes to 22,306 W of rated capacity, so the size to buy is 24,000 W, leaving 7% headroom.

Inverter or conventional

Inverter generators are quieter, produce clean power for electronics, and throttle down under light load. They cost more per watt and top out lower. For a fridge, a furnace fan and lights, an inverter unit is usually the better buy. For a well pump and central air, it usually is not.

Fuel choice is a storage decision

Gasoline makes the most power and stores the worst — it needs stabilizer and rotation. Propane stores indefinitely and costs about 10% of output. Natural gas never runs out but costs 20% and needs a gas line. Diesel lasts longest and starts worst in cold.

Notes

**Carbon monoxide kills people every storm season.** Run it outdoors only, at least 20 feet from any door, window or vent, with the exhaust pointed away from the house. Not in a garage — not even with the door open. Fit CO alarms indoors, and treat a headache during a power cut as CO until proven otherwise.
**Never back-feed.** Plugging a generator into a wall socket to power the house energises the utility line outside and can kill a lineman working to restore your power. It is illegal almost everywhere for that reason. A transfer switch or an interlock kit is the only correct connection, and it is an electrician's job.
Only the largest motor's inrush is counted, and that is deliberate. A 5 HP induction motor draws about 11,190 W for a second or two on start — roughly three times its running draw. Adding every motor's surge together, which is what most sizing tables do, buys you a generator twice the size you need and burns fuel accordingly.
Diesel: long engine life and good fuel economy; poor cold starting.
The 80% rule is not caution. A generator held at its nameplate rating runs hot, and heat is what ends them. Sizing to 14,375 W of rated capacity for 11,500 W of load is what the machine is designed around.
Inverter generators change the arithmetic. They are quieter, produce clean power for electronics, and throttle down under light load — but they cost more per watt and top out lower. For a fridge, a furnace fan and some lights, an inverter unit is usually the better buy; for a well pump and central air, it usually is not.

Nearby sizes

Roof Space for a 10 kW Array: Panel Area Is Not Roof AreaTwenty-five panels cover about 525 square feet. The roof they need is closer to 680, and the gap is mostly required by code rather than by geometry.
Daily Solar Output by Region, and the Seasonal Swing Behind the AverageAn annual average tells you what the system produces over a year. It tells you almost nothing about December, and December is where the sizing arguments happen.
How Many Panels for 1,000 kWh a MonthThe answer ranges from fifteen panels to thirty-four, for the same house using the same electricity. Location does most of that, panel wattage does the rest.
Converting kW to Panels, and the Three Ratings That Get ConfusedThree different numbers on a solar quote are all measured in kilowatts and none of them mean the same thing. Knowing which is which makes quotes comparable.